Italian Pastes
In addition to the cereals that have already been discussed, macaroni and foods of a similar nature are entitled to a place in this Section, because they are made from wheat flour and are therefore truly cereal products. These foods, which are commonly referred to as ITALIAN PASTES, originated in Italy. In that country they were made from a flour called semolina, which is derived from a native wheat that is very hard and contains more protein than is required for the making of ordinary dough mixtures. Later, when the manufacture of these foods was taken up in the United States, the flour for them had to be imported from Italy; but it has since been discovered that flour made from the variety of wheat called durum, which is grown in the spring-wheat territory of this country, can be used for producing these pastes. In fact, this kind of flour has proved to be so successful that it now takes the place of what was formerly imported.
To produce the Italian pastes, the wheat, from which the bran has been removed, is ground into flour. This flour is made into a stiff dough, which is rolled into sheets and forced over rods, usually of metal, or made into a mass and forced over rods, and allowed to dry in the air. When sufficiently dry, the rods are removed, leaving slender tubes, or sticks, that have holes through the center. Because of the manufacturing processes involved in the production of these foods for market, they are higher in price than some cereals, but their value lies in the fact that they are practically imperishable and are easily prepared and digested.
Italian pastes are of several varieties, chief among which are macaroni, spaghetti, and vermicelli. Macaroni is the largest in circumference; spaghetti, a trifle smaller; and vermicelli, very small and without a hole through the center. These pastes and variations of them are made from the same dough; therefore, the tests for determining the quality of one applies to all of them. These tests pertain to their color, the way in which they break, and the manner in which they cook. To be right, they should be of an even, creamy color; if they look gray or are white or streaked with white, they are of inferior quality. When they are broken into pieces, they should break off perfectly straight; if they split up lengthwise, they contain weak places due to streaks. All the varieties should, upon boiling, hold their shape and double in size; in case they break into pieces and flatten, they are of poor quality.
Since the Italian pastes are made from wheat, their food substances are similar to those of wheat. As in other wheat products, protein is found in them in the form of gluten, but, owing to the variety of wheat used for them, it occurs in greater proportion in these foods than in most wheat products. In fact, the Italian pastes are so high in protein, or tissue-building material, that they very readily take the place of meat. Unlike meat, however, they contain carbohydrates in the form of wheat starch. They do not contain much fat or mineral salts, though, being lower in these food substances than many of the other foods made from wheat.